White Rodgers 668-501 Kwik-Sensor CAD Cell Relays Manual de instalación descargar pdf (Pagina 1)

Printed in U.S.A.

PART NO. 37-5456A

Replaces 37-1794 &

37-9517

9510

TYPE 668

Intermittent Ignition* – Non Recycling

OIL BURNER CONTROL

With Series 956 Flame Detector

INSTALLATION INSTRUCTIONS

Operator: Save these instructions for future use!

WHITE-RODGERS DIVISION

EMERSON ELECTRIC CO.

9797 REAVIS RD., ST. LOUIS, MO. 63123

(314) 577-1300, Fax (314) 577-1517

9999 HWY. 48, MARKHAM, ONT. L3P 3J3

(905) 475-4653, FAX (905) 475-4625

DESCRIPTION

FAILURE TO READ AND FOLLOW ALL INSTRUCTIONS CAREFULLY BEFORE

INSTALLING OR OPERATING THIS CONTROL COULD CAUSE PERSONAL

INJURY AND/OR PROPERTY DAMAGE.

The proper Location and Mounting of the primary oil

burner control panel on the burner and the flame detector

with respect to the oil flame shall be determined by the

furnace, boiler, or burner manufacturer.

If this control, supplied as part of a furnace, boiler or

burner, is wired to the equipment or if the manufacturer

of such equipment provides instructions for wiring this

* Formerly called constant ignition.

SPECIFICATIONS

Electrical Data

Input voltage: 668 120V. AC, 60Hz.

668H 220V. AC, 50/60Hz.

Maximum Load Current:

Oil Burner Motor (Orange Wire):

10 Amps F.L. 60 Amps L.R.

Ignition Transformer:

360VA (3.0 Amps)

Relay Voltage: 668 24 Volts AC, 60Hz.

668H 24 Volts AC, 50/60Hz

Room Thermostat:

Set adjustable heat anticipator at 0.4 Amps. For fixed

anticipation thermostats, use 0.35 to 0.45 Amp.

heater.

Safety Timing:

668, 668H-401 to 499: 45 seconds

668, 668H-501 to 599: 30 seconds

668, 668H-601 to 699: 15 seconds

INSTALLATION AND WIRING

control, then follow his recommendations. If no special

wiring instructions are given, then follow the electrical

connections shown on this diagram for a simple system.

For more complicated systems, especially for hot water

heating, consult the manufacturer of the heating plant for

full details of the desired sequence of control operation.

To prevent electrical shock and/or equipment

damage, disconnect electric power to system, at

main fuse or circuit breaker box, until installation

is complete.

Do not use on circuits exceeding specified volt-

ages. Higher voltages will damage control and

could cause shock or fire hazard.

If in doubt about whether your wiring is millivolt, line, or

low voltage, have it inspected by a qualified heating and

air conditioning contractor, electrician, or someone famil-

iar with basic electricity and wiring.

Do not exceed the specification ratings.

All wiring must conform to local and national electrical

codes and ordinances.

This control is a precision instrument, and should be

handled carefully. Rough handling or distorting compo-

nents could cause the control to malfunction.

CAUTION

PRECAUTIONS

WARNING

WHITE-RODGERS

The type 668 Oil Burner Control provides safe operation

of oil burners on heating plants where ignition during the

entire burner cycle is desired.

The 668 is used with the 956 Flame Detector

1 2 3 4 5 6

Indice de contenidos

Pagina 1 - WHITE-RODGERS

Printed in U.S.A.PART NO. 37-5456AReplaces 37-1794 &37-95179510TYPE 668Intermittent Ignition* – Non RecyclingOIL BURNER CONTROLWith Series 956 Fla

Pagina 2 - External Line Voltage Wiring

2Possible Cause of CorrectionTroubleOpen circuit in Cell Replace Cell (or Cell Assembly)of 956 Flame Detector. Do notdisturb position of bracket orsoc

Pagina 3 - TESTING CONT

34. If safety lockout problem is of an occasional naturethe following additional check may be made toinsure that flame detector location is not a marg

Pagina 4

WHITE-RODGERSImprimé aux États-UnisNo de pièce 37-5456ARemplace : 37-1794 &37-95179510Utilisateur : conservez ces instructions pour vous y référer

Pagina 5 - AVERTISSEMENT

2Une fois l’installation complétée, il est recommandé de mettrele système à l’essai pour s’assurer de son bon fonctionnement.1. Ouvrez l’interrupteur

Pagina 6 - ESSAIS (SUITE)

3ESSAIS (SUITE)d. Si la résistance du détecteur dépasse 1000 ohms, ilest possible que celui-ci ne détecte pas très bien laflamme du brûleur. Vérifiez

Comentarios a estos manuales

Sin comentarios

Models	Document Type
DVCC32LP	Owner's Manual Empire Comfort Systems DVCC32LP Owner`s manual, 52 pages
9)0L(N	Owner's Manual Empire Comfort Systems 9)0L(N Owner`s manual, 24 pages
VFLL48SP(3	Owner's Manual Empire Comfort Systems VFLL48SP(3 Owner`s manual, 44 pages
VFD36FB2ML-1	Owner's Manual Empire Comfort Systems VFD36FB2ML-1 Owner`s manual, 20 pages
DVL33IN33N-1	Owner's Manual Empire Comfort Systems DVL33IN33N-1 Owner`s manual, 36 pages
DVP30CA30BN-2	Owner's Manual Empire Comfort Systems DVP30CA30BN-2 Owner`s manual, 24 pages
VFD32FB0F-2	Owner's Manual Empire Comfort Systems VFD32FB0F-2 Owner`s manual, 23 pages
VFLL48FP	Owner's Manual Empire Comfort Systems VFLL48FP Owner`s manual, 56 pages
DVD36FP34N-1	Owner's Manual Empire Comfort Systems DVD36FP34N-1 Owner`s manual, 44 pages
ONR-30-1	Owner's Manual Empire Comfort Systems ONR-30-1 Owner`s manual, 24 pages
VFSR-16-4	User Manual The Breckenridge Series - Percy Guidry Companies, 8 pages
BP)-1	Owner's Manual Empire Comfort Systems BP)-1 Owner`s manual, 56 pages
CP	Owner's Manual Empire Comfort Systems CP Owner`s manual, 28 pages
VFD32FB0L-3	Owner's Manual Empire Comfort Systems VFD32FB0L-3 Owner`s manual, 24 pages
VSR-30-1	User Manual The Breckenridge Series, 8 pages
VFP36PP32EP-2	Owner's Manual Empire Comfort Systems VFP36PP32EP-2 Owner`s manual, 40 pages
VFIL Series	Owner's Manual Empire Comfort Systems VFIL Series Owner`s manual, 16 pages
VFS42FB0F-4	Owner's Manual Empire Comfort Systems VFS42FB0F-4 Owner`s manual, 16 pages
BMHK-24N-1	Owner's Manual Empire Comfort Systems BMHK-24N-1 Owner`s manual, 48 pages
OP42FB2MF-2	Owner's Manual Empire Comfort Systems OP42FB2MF-2 Owner`s manual, 16 pages

White Rodgers 668-501 Kwik-Sensor CAD Cell Relays Manual de instalación Pagina 1

Busca en linea o descarga Manual de instalación para Detectores de humo White Rodgers 668-501 Kwik-Sensor CAD Cell Relays. White Rodgers 668-501 Kwik-Sensor CAD Cell Relays Installation Instructions [zh] Manual de usuario

Indice de contenidos

Comentarios a estos manuales

Empire Comfort Systems OLP42FP72S-2 manuals

Empire comfort systems OLP42FP72S-2 Owner's Manual (24 pages)

Table of contents

More products and manuals for Fireplaces Empire Comfort Systems

White Rodgers 668-501 Kwik-Sensor CAD Cell Relays Manual de instalación Pagina 1

Busca en linea o descarga Manual de instalación para Detectores de humo White Rodgers 668-501 Kwik-Sensor CAD Cell Relays. White Rodgers 668-501 Kwik-Sensor CAD Cell Relays Installation Instructions [zh] Manual de usuario

Indice de contenidos

Comentarios a estos manuales

Relacionado con productos y manuales para Detectores de humo White Rodgers 668-501 Kwik-Sensor CAD Cell Relays

Empire Comfort Systems OLP42FP72S-2 manuals

Empire comfort systems OLP42FP72S-2 Owner's Manual (24 pages)

Table of contents

More products and manuals for Fireplaces Empire Comfort Systems